EFTA00798623.pdf

14, Work Order Detail comlux Project: 1999M Aircraft: 737 - 32806 Repair Station: 166-CAY-AMO-20 Task Card # Task ID Opened RTS Closed Task Card: 10 Drawing: IPA 12/12/2016 07/11/2018 Description: Satcom Antenna Repair/ Service upgrade 505-AVIONICS, Mx 1999M.10.505 5093713 12/12/2016 01/09/2018 01/10/2018 Description: Satcom Antenna Repair/ Service upgrade 505-1-AVIONICS, Mx 1999M.10.505.1 5105793 07/10/2018 07/11/2018 Description: Due to serviceable right hand antenna not being available. design and perform procedures to deactivate the Satcom system before next flight Count: 2 1 2 Task Card: 11 Drawing: N/A 12/12/2016 06/15/2018 Description: TCAS 7.1 Upgrade PIN 822-2911-002 to 822-2911-002 505-AVIONICS, Mx 1999M.11.50 5093714 12/12/2016 06/01/2018 06115/2018 Description: TCAS 7.1 Upgrade PIN 822-2911-002 to 822-2911-002 Count: 1 1 1 Task Card: 12 Drawing: N/A 1 12/12/2016 11/17/2017 Description: 081001 - PERFORM AIRCRAFT WEIGHT AND BALANCE 801-Maintenance 1999M.12.80 5093715 12/12/2016 11/16/2017 11/17/2017 Description: 081001 - PERFORM AIRCRAFT WEIGHT AND BALANCE Count: 1 1 1 Task Card: 19 Drawing: N/A 12/12/2016 11/1712017 Description: TCAS Boeing Service Bulletin 505-AVIONICS, Mx 1999M.19.50 5093717 12/12/2016 11/16/2017 11/17/2017 Description: TCAS Boeing Service Bullets, Count: 1 1 1 Printed: 8/2712018 1:23:21PM Page 1 of 126 EFTA00798623  Project: 1999M 0comlux Work Order Detail Aircraft: 737 - 32806 Repair Station: 166-CAY-AMO-20 Task Card # Task ID Opened RTS Closed Task Card: 18 Drawing: N/A 12112/2016 Description: A2 Check 80-12-Maintenance 1999M.1B.80-12 5094030 12/1212016 03/10/2017 03/10/2017 Description: 72-020-01: DETAILED INSPECTION OF LEFT ENGINE INLET AND FAN BLADES. 80-13-Maintenance 1999M.1B.80-13 5094031 12/12(2016 03/10/2017 03/10/2017 Description: 72-020-02: DETAILED INSPECTION OF RIGHT ENGINE INLET AND FAN BLADES 205-INTERIOR INSTALL, Mx 1999M.1B.20 5094032 12/12(2016 04/05/2017 04/05/2017 Desaiption: 25 020-00-01: INSPECT (DETAILED) THE CAPTAIN, FIRST OFFICER, FIRST OBSERVER AND SECOND OBSERVER (IF INST... 505-AVIONICS, Mx 1999M.1B.50 5094033 12/1212016 02/23/2017 02/23/2017 Description: 28 054-00-01: OPERATIONALLY (BITE) CHECK THE FUEL PUMP GFI RELAY. SPECIAL NOTE: AWL TASK (28-AWL-20) IN... 505-1-AVIONICS, Mx 1999M.1B.50-1 5094034 12/1212016 01/05/2018 01/08/2018 Description: 28 058-00-01: FUNCTIONALLY CHECK CENTER TANK FUEL BOOST PUMP POWER FAILED ON PROTECTION SYSTEM. SPECIAL... 505-2-AVIONICS, Mx 1999M.1B.50-2 5094035 12/1212016 02/23/2017 02/23/2017 Description: 33 055-00-02: FUNCTIONALLY CHECK THE EMERGENCY LIGHTS BATTERY PACKS FOR CAPACITY (15 MIN. MINIMUM) AND O... 805-3-Mx Interiors 1999M.1B.805-3 5094036 12/1212016 Description: 387002: REPLACE WATER FILTER CARTRIDGE 80-Maintenance 1999M.1B.80 5094037 12/1212016 Description: 050012: ACCOMPLISH A2 CHECK 80-1-Maintenance 1999M.1B.80-1 5094038 12/1212016 03/27/2017 03/27/2017 Description: 27 170-01-01: LUBRICATE THE LEFT WING TRAILING EDGE FLAP ACTUATION MECHANISM. 80-2-Maintenance 1999M.1B.80-2 5094039 12/1212016 03/27/2017 03/27/2017 Description: 27170-02-01: LUBRICATE THE RIGHT WING TRAILING EDGE FLAP ACTUATION MECHANISM. 80-3-Maintenance 1999M.1B.80-3 5094040 12/1212016 01/12/2018 01/16/2018 Description: 28115-0-01: FUNCTIONALLY CHECK THE CENTER TANK BOOST PUMP AUTO SHUTOFF SYSTEM. NOTE: TASK MEETS INTENT... 80-4-Maintenance 1999M.1B.80-4 5094041 12/1212016 Description: 28 20-01-PATS OPERATIONAL CHECK OF THE AUXILIARY FUEL CONTROL UNIT 80-5-Maintenance 1999M.151.80-5 5094042 12/1212016 03/27/2017 03/27/2017 Description: 52 150-00-01: LUBRICATE THE AIRSTAIR DOOR SYSTEM, (INCLUDES TWO ROLLERS, THE CARRIAGE DRIVE BALL BEARING... 80-6-Maintenance 1999M.1B.80-6 5094043 12/1212016 03/27/2017 03/27/2017 Description: 57 952-01-01: INTERNAL - ZONAL (GV): LEFT WINGLET. TASK IS EQUIVALENT TO APB TASK 57-944-01 REF APB MAIN... 80-7-Maintenance 1999M.1B.80-7 5094044 12/12/2016 04/04/2017 04/04/2017 Description: 57 962-02-01: INTERNAL - ZONAL (GV): RIGHT WINGLET. TASK IS EQUIVALENT TO APB TASK 57-948-01 REF APB MN... 80-8-Maintenance 1999M.1B.80-8 5094045 12/1212016 02/28/2017 02/28/2017 Description: 72 020-01-01 DETAILED INSPECTION OF NO. 1 ENGINE INLET AND FAN BLADES. 80-9-Maintenance 1999M.1B.80-9 5094046 12/12(2016 03/10/2017 03/10/2017 Description: 72 020-02-01 DETAILED INSPECTION OF NO. 2 ENGINE INLET AND FAN BLADES. Printed: 8127/2018 1:23:21PM Page 2 of 126 EFTA00798624  Project: 1999M 0 Work Order Detail Aircraft: 737 - 32806 Repair Station: 166-CAY-AMO-20 conli1PC Task Card # Task ID Opened RTS Closed 80-10-Maintenance 1999M.1B.80.10 5094047 12/12/2016 01/03/2018 01/05/2018 Description: 23-110-00 (FM 91.207): INSPECT (FIXED) EMERGENCY LOCATOR TRANSMITTER IAW FAR 91.207(D) 701-11-SYSTEM SHOP, FABRICATE 1999M.1B.701.11 5094048 12/12/2016 Description: 387001 :OPERATIONAL CHECK POTABLE WATER SYSTEM 80-14-Maintenance 1999M.1B.80-14 5094049 12/12/2016 08/10/2017 08/10/2017 Description: 72-180-01: NO. 1 ENGINE - BORESCOPE COMBUSTION CHAMBER 80-15-Maintenance 1999M.1B.80-15 5094050 12/12/2016 08/10/2017 10/19/2017 Description: 72-180-01: NO. 2 ENGINE - BORESCOPE COMBUSTION CHAMBER 80-16-Maintenance 1999M.18.80-16 5094051 12/12/2016 07/29/2017 07/29/2017 Description: 72-200-01: NO. 1 ENGINE - BORESCOPE HIGH PRESSURE TURBINE NOZZLE 80-17-Maintenance 1999M.18.80-17 5094052 12/12/2016 07/29/2017 07/29/2017 Description: 72-200-01: NO. 2 ENGINE - BORESCOPE HIGH PRESSURE TURBINE NO 71 F 80-18-Maintenance 1999M.1B.80-18 5094053 12/12(2016 07/29/2017 07/29/2017 Description: 72-210-01: NO. 1 ENGINE - BORESCOPE HIGH PRESSURE TURBINE BLADES 80-19-Maintenance 1999M.1B.80-19 5094054 12/12(2016 07/29/2017 07/29/2017 Description: 72-210-01: NO. 2 ENGINE - BORESCOPE HIGH PRESSURE TURBINE BLADES Count: 25 25 21 Task Card: 18.50-2.NR-1 Drawing: N/A 03/16/2017 06/15/2018 Description: DURING TEST OF EMER LIGHTS CAPACITY CHECK THE FOLLOWING LIGHTS FAILED. LH & RH OVERW1N LIGHTS. ALL FLOOR EMER LIGHTS. 505-20-AVIONICS. Mx 1999M.18.50-2.NR-1.50-20 5096681 03/16/2017 01/08/2018 06/15/2018 Description: DURING TEST OF EMER LIGHTS CAPACITY CHECK THE FOLLOWING LIGHTS FAILED, LH & RH OVERWIN LIGHTS, ALL FLOOR EMER LIGHTS. Count: 1 1 1 • • Task Card: 18.701-11.NR-1 Drawing: N/A 06/27/2018 Description: Water Heater leaking aft lavatory- leaking water beyond AMM limits 701-27-SYSTEM SHOP, FABRICATE 1999M.18.701-11.NR-1.701-27 5111752 06/2712018 Description: Water Heater leaking aft lavatory- leaking water beyond AMM limits Count: 1 1 0 Task Card: 18.701-11.NR-2 Drawing: N/A 06/27/2018 Description: Broken water Selector Valve Fwd Crew Lay. leakrig static beyond AMM units 701-28SYSTEM SHOP, FABRICATE 1999M.18.701-11.NR-2.701-28 5111754 06/27/2018 Description: Broken water Selector Valve Fwd Crew Lsv. leakrig static beyond AMM limits Count: 1 1 0 Printed: 8/27/2018 1:23:21PM Page 3 of 126 EFTA00798625  Project: 1999M Work Order Detail Aircraft: 737 - 32806 comlux Repair Station: 166-CAY•AMO•20 Task Card # Task ID Opened RTS Closed Task Card: 18.80-2.NR-1 Drawing: N/A 04/05/2017 01/10/2018 Description: RT VB FLAP OfB FLAP FAIRING SEAL IS TORN. 80-23-Maintenance 1999M.18.80-2.NR-1.80-23 5097835 04/05/2017 01/09/2018 01/10/2018 Descaption: RT VB FLAP OfB FLAP FAIRING SEAL IS TORN. Count: 1 1 1 Task Card: 18.80-2.NR-2 Drawing: N/A 04/04/2017 05/10/2017 Descoption: ALL RT FLAP (UN 8 On3) TRACKS REQUIRE REMOVAL OF OLD GREASE FROM FLAP TRACK FLANGES. 801-24-Maintenance 1999M.18.80-2.NR-2.801-24 5097836 04/04(2017 05/10/2017 05/10/2017 Description: ALL RT FLAP (UN 8 018) TRACKS REQUIRE REMOVAL OF OLD GREASE FROM FLAP TRACK FLANGES. Count: 1 1 1 Task Card: 18.80-2.NR-3 Drawing: N/A 04/05/2017 04/18/2017 Description: RT OM FLAP IfB MAIN FLAP CARRIAGE SEAL RETAINER UNDER DUST CAP IS NO LONGER ENGAGED. 80-25-Maintenance 1999M.18.80-2.NR-3.80-25 5097837 04/05(2017 04/18/2017 04/18/2017 Descaption: RT Ort3 FLAP la MAIN FLAP CARRIAGE SEAL RETAINER UNDER DUST CAP IS NO LONGER ENGAGED. Count: 1 1 1 Task Card: 18.80-5.NR-1 Drawing: N/A 04/0512017 01/04/2018 Descaption: AIRSTAIR DOOR LOCKPIN HAS A CHIP OUT OF THE CORNER OF THE PIN. 80.21-Maintenance 1999M.18.80-5.NR-1.80-21 5097832 04/05/2017 01/03/2018 01/04/2018 Description: AIRSTAIR DOOR LOCKPIN HAS A CHIP OUT OF THE CORNER OF THE PIN. Count: 1 1 1 Task Card: 18.80-5.NR-2 Drawing: N/A 04/03/2017 Description: AIRSTAIR HANDRAIL FORWARD AND AFT UPPER SUPPORT RODS ARE CRACKED. 80.22-Maintenance 1999M.18.80-5.NR-2.80-22 5097833 04/03/2017 Description: AIRSTAIR HANDRAIL FORWARD AND AFT UPPER SUPPORT RODS ARE CRACKED. Count: 1 1 0 Task Card: 18.80-5.NR-3 Drawing: N/A 10/11/2017 01105/2018 Description: While replacing airstair outer door lockpin found target support bracket for door warning system damaged 80-26-Maintenance 1999M.18.80-5.NR-3.80-26 5102968 10/11/2017 01/04/2018 01/05/2018 Descnp6on: While replacing airstair outer door lockpin found target support bracket for door warning system damaged Count: 1 1 1 Printed: 8127/2018 1:23:21PM Page 4 of 126 EFTA00798626  Project: 1999M Work Order Detail Aircraft: 737 • 32806 comlux Repair Station: 166-CAY-AMO-20 Task Card # Task ID Opened RTS Closed Task Card: 1C Drawing: N/A 12/12/2016 Description: Cl check 505-AVIONICS, Mx 1999M.1C.50 5093755 12/12/2016 04/11/2017 04/11/2017 Description: 24-130-00: FUNCTIONAL CHECK OF THE EXTERNAL POWER RECEPTACLE PINS FOR EXCESSIVE WEAR 505-1-AVIONICS, Mx 1999M.1C.50-1 5093756 12/12/2016 03/02/2017 03/02/2017 Description: 24-140-00: DETAILED INSPECTION OF THE EXTERNAL POWER RECEPTACLE PINS FOR SIGNS OF OVERHEAT AND SECURITY OF INSTALLATION. 80-50-Maintenance 1999M.1C.80-50 5093757 12/12/2016 03/23/2017 03/23/2017 Description: 52-020-00LUBRICATE THE FWD SERVICE DOOR GUIDE PLATE AND ARM ASSEMBLIES. TORQUE TUBE BUSHINGS. THE UPPER AND LOWER HINGE ARMS. GATE HINGES. 80-51-Maintenance 1999M.1C.80-51 5093758 12/12/2016 04/11/2018 04/12/2018 Description: 52-020-00LUBRICATE THE AFT ENTRY DOOR GUIDE PLATE AND ARM ASSEMBLIES. TORQUE TUBE BUSHINGS. THE UPPER AND LOWER HINGE ARMS. GATE HINGES. 80-52-Maintenance 1999M.1C.80-52 5093759 12/12/2016 06/20/2018 06/21/2018 Description: 52-020-00LUBRICATE THE AFT SERVICE DOOR GUIDE PLATE AND ARM ASSEMBLIES. TORQUE TUBE BUSHINGS. THE UPPER AND LOWER HINGE ARMS. GATE HINGES. 80-53-Maintenance 1999M.1C.80-53 5093760 12/12/2016 03/13/2017 03/13/2017 Description: 52-030-00INSPECT (DETAILED) THE FORWARD ENTRY DOOR CENTERING GUIDE STUD AND NYLON TRACK PADS FOR CONDITION. 80-54-Maintenance 1999M.1C.80-54 5093761 12/12/2016 03/23/2017 03/23/2017 Description: 52-040-00INSPECT (DETAILED) THE FWD SERVICE DOOR CENTERING GUIDE BEARINGS 80.55-Maintenance 1999M.1C.80-55 5093762 12/12/2016 03/13/2017 03/13/2017 Description: 52-040-00INSPECT (DETAILED) THE AFT ENTRY DOOR CENTERING GUIDE BEARINGS 80-56-Maintenance 1999M.1C.80-56 5093763 12/12/2016 03/13/2017 03/13/2017 Description: 52-040-00INSPECT (DETAILED) THE AFT SERVICE DOOR CENTERING GUIDE BEARINGS 80.57-Maintenance 1999M.1C.80-57 5093764 12/12/2016 03/23/2017 03/23/2017 Description: 52-090-00LUBRICATE THE FWD CARGO COMPARTMENT DOOR LATCH TORQUE TUBE BEARINGS AND THE COUNTER BALANCE MAIN BEARINGS. 80-58-Maintenance 1999M.1C.80-58 5093765 12/12/2016 03/23/2017 03/23/2017 Description: 52-090-00LUBRICATE THE AFT CARGO COMPARTMENT DOOR LATCH TORQUE TUBE BEARINGS AND THE COUNTER BALANCE MAIN BEARINGS. 80-59-Maintenance 1999M.1C.80-59 5093766 12/12/2016 03/24/2017 03/24/2017 Description: 52-120-00LUBRICATE THE EYE ACCESS DOOR HANDLE LATCHING MECHANISM (RACK AND PINION GEAR AND LOCK PINS). 80.60-Maintenance 1999M.1C.80-60 5093767 12/12/2016 04/03/2017 04/03/2017 Description: 52-160-00LUBRICATE THE AIRSTAIR SYSTEM. 80-61-Maintenance 1999M.1C.80-61 5093768 12/12/2016 02/23/2017 02/23/2017 Description: 52-220-000PERATIONALLY CHECK (CYCLE) THE AUTOMATIC OVERWING EMERGENCY EXIT DOORS. 80-62-Maintenance 1999M.1C.80-62 5093769 12/12/2016 03/24/2017 03/24/2017 Description: 52-230-000ETAILED VISUAL INSPECTION OF THE AUTO OVERWING EMERGENCY EXIT DOOR LATCH ROLLERS. LINKS.AND PIVOT FITTINGS/JOINTS. 80.63-Maintenance 1999M.1C.80-63 5093770 12/12/2016 03/24/2017 03/24/2017 Printed: 8/27/2018 1:23:21PM Page 5 of 126 EFTA00798627  Project: 1999M 0 Work Order Detail comlux Aircraft: 737 - 32806 Repair Station: 166-CAY-AMO-20 Task Card N Task ID Opened RTS Closed Description: 52-240-000PERATIONALLY CHECK THE FLIGHT LOCK ENGAGEMENT AND DISENGAGEMENT. 80-64-Maintenance 1999M.1C.80-64 5093771 12/12/2016 03/24/2017 03/24/2017 Description: 52-250-00PERFORM A DETAILED VISUAL INSPECTION OF AUTOMATIC OVERWING EXIT DOOR FLIGHT LOCKS FOR CORROSION AND CONDITION. 80-65-Maintenance 1999M.1C.80-65 5093772 12/12/2016 04/03/2017 04/03/2017 Description: 52-280-00INSPECT (GENERAL VISUAL) THE AUTOMATIC EMERGENCY EXIT DOOR PRESSURE SEALS FOR DEGRADATION. 80-66-Maintenance 1999M.1C.80-66 5093773 12/12(2016 03/24/2017 03/24/2017 Desaiption: 52-510-00EXTERNAL - DETAILED: FORWARD ACCESS DOOR 80-67-Maintenance 1999M.1C.80-67 5093774 12/1212016 03/24/2017 03/24/2017 Description: 52-540-00EXTERNAL - DETAILED: EiE EQUIPMENT COMPARTMENT ACCESS DOOR 80-68-Maintenance 1999M.1C.80-68 5093775 12/1212016 03/24/2017 03/24/2017 Description: 52-580-00EXTERNAL - DETAILED: FORWARD AIRSTAIRS DOOR 80-69-Maintenance 1999M.1C.80-69 5093776 12/1212016 04/03/2017 04/03/2017 Description: 52-590-00EXTERNAL - GENERAL VISUAL FORWARD AIRSTAIRS DOOR 80-70-Maintenance 1999M.1C.80-70 5093777 12/1212016 03/13/2017 03/13/2017 Description: 52-610-00EXTERNAL - DETAILED: FORWARD ENTRY DOOR 80-71-Maintenance 1999M.1C.80-71 5093778 12/1212016 03/24/2017 03/24/2017 Description: 52-610-00EXTERNAL - DETAILED: FORWARD SERVICE DOOR 80-72-Maintenance 1999M.1C.80-72 5093779 12/12(2016 03/13/2017 03/13/2017 Description: 52-610-00EXTERNAL - DETAILED: AFT ENTRY DOOR 80-73-Maintenance 1999M.1C.80-73 5093780 12/12(2016 03/13/2017 03/13/2017 Description: 52-610-00EXTERNAL - DETAILED: AFT SERVICE DOOR 80-74-Maintenance 1999M.1C.80-74 5093781 12/12(2016 03/13/2017 03/13/2017 Description: 52-670-00EXTERNAL - DETAILED: FORWARD CARGO DOOR 80-75-Maintenance 1999M.1C.80-75 5093782 12/1212016 03/13/2017 03/13/2017 Desaiption: 52-670-00EXTERNAL - DETAILED: AFT CARGO DOOR 80-76-Maintenance 1999M.1C.80-76 5093783 12/1212016 03/24/2017 03/24/2017 Description: 52-730-00EXTERNAL - DETAILED: AUTOMATIC OVERWING EMERGENCY EXIT HATCHES/AUTOMATIC OVERWING EXIT DOOR 80-77-Maintenance 1999M.1C.80-77 5093784 12/1212016 03/24/2017 03/24/2017 Desaiption: 52-730-00EXTERNAL - DETAILED: AUTOMATIC OVERWING EMERGENCY EXIT HATCHES/AUTOMATIC OVERWING EXIT DOOR 80-78-Maintenance 1999M.1C.80-78 5093785 12/1212016 04/05/2017 04/05/2017 Description: 52-804-02INTERNAL - ZONAL (GV): FORWARD CARGO DOOR 80-79-Maintenance 1999M.1C.80-79 5093786 12/1212016 04/03/2017 04/03/2017 Description: 52-808-02INTERNAL - ZONAL (GV): AFT CARGO DOOR 80-80-Maintenance 1999M.1C.80-80 5093787 12/12(2016 04/03/2017 04/03/2017 Desaiption: 52-812-01INTERNAL - ZONAL (GV): FORWARD PASSENGER ENTRY DOOR 80-81-Maintenance 1999M.1C.80-81 5093788 12/12(2016 04/03/2017 04/03/2017 Description: 52-814-01EXTERNAL - ZONAL (GV): AUTOMATIC OVERWING EXIT. PERFORM AN EXTERNAL ZONAL INSPECTION (GV) OF THE AUTOMATIC OVERWING EXIT -SECTION 44. STA 589.5 80-82-Maintenance 1999M.1C.80-82 5093789 12/12/2016 04/03/2017 04/03/2017 Printed: 8/27/2018 1:23:21PM Page 6 of 126 EFTA00798628  Project: 1999M 0comlux Work Order Detail Aircraft: 737 - 32806 Repair Station: 166-CAY-AMO-20 Task Card A Task ID Opened RTS Closed Description: 52-818-01EXTERNAL -ZONAL (GV): AUTOMATIC OVERWING EMERGENCY EXIT 80-83-Maintenance 1999M.1C.80-83 5093790 12/1212016 04/03/2017 04/03/2017 Description: 52-824-01INTERNAL - ZONAL (GV): AFT PASSENGER ENTRY DOOR 80-84-Maintenance 1999M.1C.80-84 5093791 12/12/2016 04/03/2017 04/03/2017 Description: 52-828-02EXTERNAL - ZONAL (GV): FORWARD GALLEY SERVICE DOOR.PERFORM AN EXTERNAL ZONAL INSPECTION (GV) OF THE FORWARD GALLEY SERVICE DOOR - SECTION 41, STA 340. 80-85-Maintenance 1999M.1C.80-85 5093792 12/12/2016 04/05/2017 04/05/2017 Description: 52-828-02INTERNAL - ZONAL (GV): FORWARD SERVICE DOOR 80-86-Maintenance 1999M.1C.80-136 5093793 12/12/2016 04/03/2017 04/03/2017 Description: 52-830-02EXTERNAL - ZONAL (GV): AUTOMATIC OVERWING EMERGENCY EXIT (NOTE: -800. BBJ2 AIRCRAFT ONLY). 80-87-Maintenance 1999M.1C.80-87 5093794 12/12/2016 04/03/2017 04/03/2017 Description: 52-834-02EXTERNAL - ZONAL (GV): AUTOMATIC OVERWING EMERGENCY EXIT 80-88-Maintenance 1999M.1C.80-88 5093795 12/1212016 04/03/2017 04/03/2017 Description: 52-838-02EXTERNAL - ZONAL (GV): AFT GALLEY SERVICE DOOR.PERFORM AN EXTERNAL ZONAL INSPECTION (GV) OF THE AFT GALLEY SERVICE DOOR - SECTION 47, STA 980. 80-89-Maintenance 1999M.1C.80-89 5093796 12/1212016 04/05/2017 04/05/2017 Description: 52-840-02INTERNAL - ZONAL (GV): AFT SERVICE DOOR 80-90-Maintenance 1999M.1C.80-90 5093797 12/1212016 03/13/2017 03/13/2017 Description: 53-030-00EXTERNAL - DETAILED:CARGO DOOR SURROUND STRUCTURE FITTINGS AND STOPS INSPECT FORWARD CARGO DOOR SURROUND STRUCTURE FIRINGS AND STOPS. 80-91-Maintenance 1999M.1C.80-91 5093798 12/1212016 03/13/2017 03/13/2017 Description: 53-030-00EXTERNAL - DETAILED:CARGO DOOR FRAME SURROUND STRUCTURE FIRINGS AND STOPS INSPECT AFT CARGO DOOR SURROUND STRUCTURE FITTINGS AND STOPS. 80-92-Maintenance 1999M.1C.80-92 5093799 12/1212016 03/24/2017 03/24/2017 Description: 53-310-00EXTERNAL- DETAILED: FORWARD ENTRY DOOR FRAME, STOPS, LATCHES AND HINGES 80-93-Maintenance 1999M.1C.80-93 5093800 12/1212016 03/24/2017 03/24/2017 Description: 53-310-00EXTERNAL- DETAILED: FORWARD SERVICE DOOR FRAME. STOPS. LATCHES AND HINGES 80-94-Maintenance 1999M.1C.80-94 5093801 12/1212016 03/24/2017 03/24/2017 Description: 53-310-00EXTERNAL- DETAILED: AFT ENTRY DOOR FRAME, STOPS, LATCHES AND HINGES 80-95-Maintenance 1999M.1C.80-95 5093802 12/12/2016 03/24/2017 03/24/2017 Description: 53-310-00EXTERNAL- DETAILED: AFT SERVICE DOOR FRAME, STOPS, LATCHES AND HINGES 80-96-Maintenance 1999M.1C.80-96 5093803 12/1212016 04/05/2017 04/05/2017 Description: 53-802-00PERFORM AN INTERNAL ZONAL INSPECTION (GV) OF THE RADOME 80-97-Maintenance 1999M.1C.80-97 5093804 12/1212016 04/03/2017 04/03/2017 Desaiption: 53-804-00INTERNAL - ZONAL (GV): AREA FORWARD OF NOSE WHEEL WELL PERFORM AN INTERNAL ZONAL INSPECTION (GV) OF THE AREA FORWARD OF THE NOSE WHEEL WELL - SECTION 41, STA 178 TO STA 224.8. (EZAP) THIS EZAP INSPECTION REQUIREMENT WITH INTERVAL 38000 FC/12 YR IS SATISFIED BY THIS ZONAL INSPECTION. 80-98-Maintenance 1999M.1C.8098 5093805 12/1212016 04/03/2017 04/03/2017 Printed: 8/27/2018 1:23:21PM Page 7 of 126 EFTA00798629  Project: 1999M Work Order Detail Aircraft: 737 - 32806 comlux Repair Station: 166-CAY-AM0.20 Task Card # Task ID Opened RTS Closed Description: 53-806-00INTERNAL - ZONAL (GV): AREA ABOVE AND OUTBOARD OF NOSE WHEEL WELL. PERFORM AN INTERNAL ZONAL INSPECTION (GV) OF THE AREA ABOVE AND OUTBOARD OF THE NOSE WHEEL WELL. (EZAP) THE EZAP INSPECTION REQUIREMENT WITH INTERVAL 36000 FC/12 YR IS SATISFIED BY THIS ZONAL INSPECTION 80-99-Maintenance 1999M.1C.80-99 5093806 12/1212016 04/03/2017 04/03/2017 Description: 53-808-00INTERNAL - ZONAL (GV): ELECTRICAL AND ELECTRONICS COMPARTMENT. PERFORM AN INTERNAL ZONAL INSPECTION (GV) OF THE ELECTRICAL AND ELECTRONICS COMPARTMENT. (EZAP) THE EZAP INSPECTION REQUIREMENT WITH INTERVAL 18000 FC/6 YR IS SATISFIED BY THIS ZONAL INSPECTION. ACCESS NOTE: FORWARD AIRSTAIR DRIP PAN ACCESS PANEL MUST BE REMOVED IF AIRSTAIR INSTALLED. 80-100-Maintenance 1999M.1C.80-100 5093807 12/1212016 03/07/2017 03/07/2017 Description: 53-810-00INTERNAL - ZONAL (GV): ELECTRICAL AND ELECTRONICS COMPARTMENT ACCESS DOOR 80-101-Maintenance 1999M.1C.80-101 5093808 12/1212016 02/23/2017 02/23/2017 Description: 53-818-00EXTERNAL - ZONAL (GV):FORWARD CARGO DOOR SURROUND STRUCTURE FITTINGS AND STOPS 80-102-Maintenance 1999M.1C.80-102 5093809 12/1212016 04/03/2017 04/03/2017 Description: 53-828-00INTERNAL - ZONAL (GV): KEEL BEAM (PART) STA 540 TO 727. PERFORM AN INTERNAL ZONAL INSPECTION (GV) OF THE KEEL BEAM (PART) STA 540 TO 727 - SECTION 44. (EZAP) THE EZAP INSPECTION REQUIREMENT WITH INTERVAL 36000 FC/12 YR IS SATISFIED BY THIS ZONAL INSPECTION. 80-103-Maintenance 1999M.1C.80-103 5093810 12/1212016 02/23/2017 02/23/2017 Desaiption: 53-83600PERF0RM AN EXTERNAL ZONAL INSPECTION (GV) OF THE AFT CARGO DOOR SURROUND STRUCTURE FITTINGS & STOPS - SECTION 48, STA 827 80-104-Maintenance 1999M.1C.80-104 5093811 12/1212016 03/16/2017 03/16/2017 Description: 53-83800PERF0RM AN INTERNAL ZONAL INSPECTION (GV) OF THE AFT CARGO COMPARTMENT VACUUM WASTE COMPARTMENT. ACCESS NOTE: VACUUM WASTE COMPARTMENT PANELS REMOVAL REQUIRED. 80-105-Maintenance 1999M.1C.80-105 5093812 12/1212016 04/03/2017 04/03/2017 Description: 53-842-00INTERNAL - ZONAL (GV): AFT CARGO COMPARTMENT EQUIPMENT BAY PERFORM AN INTERNAL ZONAL INSPECTION (GV) OF THE AFT CARGO COMPARTMENT EQUIPMENT BAY - SECTION 47. STA 947.5 TO AFT PRESSURE BULKHEAD. (EZAP) 80-106-Maintenance 1999M.1C.80-106 5093813 12/12/2016 04/03/2017 04/03/2017 Description: 53-846-00INTERNAL - ZONAL (GV): LOWER WING TO BODY FAIRING - FORWARD OF WING BOX. PERFORM AN INTERNAL ZONAL INSPECTION (GV) OF THE LOWER WING TO BODY FAIRING - FORWARD OF WING BOX. (EZAP) THE EZAP INSPECTION REQUIREMENT WITH INTERVAL 36000 FC/12 YR IS SATISFIED BY THIS ZONAL INSPECTION. 80-107-Maintenance 1999M.1C.80-107 5093814 12/1212016 04/03/2017 04/03/2017 Description: 53-848-00INTERNAL - ZONAL (GV): LOWER WING TO BODY FAIRING - UNDER WING BOX. PERFORM AN INTERNAL ZONAL INSPECTION (GV) OF THE LOWER WING TO BODY FAIRING - UNDER THE WING BOX. (EZAP) THE EZAP INSPECTION REQUIREMENT WITH INTERVAL 18000 FC/6 YR IS SATISFIED BY THIS ZONAL INSPECTION. 80-108-Maintenance 1999M.1C.80-108 5093815 12/1212016 04/03/2017 04/03/2017 Description: 53-852-00INTERNAL - ZONAL (GV): LOWER WING TO BODY FAIRING - AFT OF WHEEL WELL 80-109-Maintenance 1999M.1C.80-109 5093816 12/1212016 04/19/2017 04/19/2017 Description: 53-858-00EXTERNAL - ZONAL (GV): FLIGHT CONTROL COMPARTMENT PERFORM AN EXTERNAL ZONAL INSPECTION (GV) OF THE FLIGHT CONTROL COMPARTMENT - SECTION 41, STA 178 TO STA 270 Printed: 8(27/2018 1:23:21PM Page 8 of 126 EFTA00798630  Project: 1999M fcomluxWork Order Detail Aircraft: 737 - 32806 Repair Station: 166-CAY-AMO-20 Task Card # Task ID Opened RTS Closed 80-110-Maintenance 1999M.1C.80-110 5093817 12/12(2016 04/0312017 04/03./2017 Description: 53-860-00INTERNAL - ZONAL (GV): FLIGHT CONTROL COMPARTMENT PERFORM AN INFERNAL ZONAL INSPECTION (GV) OF THE FLIGHT CONTROL COMPARTMENT - SECTION 41, STA 178 TO STA 270. 80-111-Maintenance 1999M.1C.80-111 5093818 12/12/2016 04/19/2017 04/19/2017 Description: 53-884-00EXTERNAL - ZONAL (GV): PASSENGER COMPARTMENT - AFT OF CONTROL COMPARTMENT TO FWD ENTRY DOOR PERFORM AN EXTERNAL ZONAL INSPECTION (GV) OF THE PASSENGER COMPARTMENT - AFT OF THE CONTROL COMPARTMENT TO FORWARD ENTRY DOOR - LEFT AND RIGHT - SECTION 41, STA 270 TO STA 380 80-112-Maintenance 1999M.1C.80-112 5093819 12/1212016 04/03/2017 04/03/2017 Description: 53-866-00INTERNAL - ZONAL (GV): PASSENGER COMPARTMENT -SECTION 41, STA 270 TO STA 360. PERFORM AN INTERNAL ZONAL INSPECTION (GV) OF THE PASSENGER COMPARTMENT - SECTION 41, STA 270 TO STA 360. 80-113-Maintenance 1999M.1C.80-113 5093820 12/1212016 04/03/2017 04/03/2017 Description: 53-870-00EXTERNAL - ZONAL (GV): FORWARD PASSENGER ENTRY DOOR STOPS, LATCHES, AND HINGES 80-114-Maintenance 1999M.1C.80-114 5093821 12/1212016 03/24/2017 03/24/2017 Description: 53-872-00EXTERNAL - ZONAL (GV): FORWARD SERVICE DOOR STOPS. LATCHES. AND HINGES 80-115-Maintenance 1999M.1C.80-115 5093822 12/1212016 04/19/2017 04/19/2017 Description: 53-874-00EXTERNAL - ZONAL (GV): FORWARD PASSENGER COMPARTMENT - STA 380 TO STA 663.75 80-116-Maintenance 1999M.1C.80-116 5093823 12/12(2016 04/03/2017 04/03/2017 Description: 53-876-00INTERNAL - ZONAL (GV): FORWARD PASSENGER COMPARTMENT - STA 360 TO STA 663.75 80-117-Maintenance 1999M.1C.80-117 5093824 12/1212016 04/19/2017 04/19/2017 Description: 53-882-00EXTERNAL - ZONAL (GV): AFT PASSENGER COMPARTMENT - STA 663.75 TO AFT PRESSURE BULKHEAD 80-118-Maintenance 1999M.1C.80-118 5093825 12/1212016 04/03/2017 04/03/2017 Description: 53-884-00INTERNAL - ZONAL (GV): AFT PASSENGER COMPARTMENT - STA 683.75 TO AFT PRESSURE BULKHEAD 80-119-Maintenance 1999M.1C.80-119 5093826 12/1212016 04/03/2017 04/03/2017 Description: 53-890-00EXTERNAL - ZONAL (GV): AFT PASSENGER ENTRY DOOR STOPS. LATCHES, AND HINGES 80-120-Maintenance 1999M.1C.80-120 5093827 12/1212016 04/03/2017 04/03/2017 Description: 53-892-00EXTERNAL - ZONAL (GV): AFT SERVICE DOOR STOPS, LATCHES. AND HINGES 80-121-Maintenance 1999M.1C.80-121 5093828 12/1212016 10/19/2017 10/20/2017 Description: 53-896-00INTERNAL - ZONAL (GV): AREA AFT OF PRESSURE BULKHEAD. PERFORM AN INTERNAL ZONAL INSPECTION (GV) OF THE AREA AFT OF PRESSURE BULKHEAD - SECTION 48. AFT OF AFT PRESSURE BULKHEAD TO STA 1088. (EZAP) THE EZAP INSPECTION REQUIREMENT WITH INTERVAL 38000 FC/12 YR IS SATISFIED BY THIS ZONAL INSPECTION. 80-122-Maintenance 1999M.1C.80-122 5093829 12/1212016 04/05/2017 04/05/2017 Description: 53-898-00INTERNAL - ZONAL (GV): STABILIZER TORSION BOX COMPARTMENT. PERFORM AN INTERNAL ZONAL INSPECTION (GV) OF THE STABILIZER TORSION BOX COMPARTMENT - SECTION 48. STA 1088 TO STA 1156. (EZAP) THE EZAP INSPECTION REQUIREMENT WITH INTERVAL 36000 FC/12 YR IS SATISFIED BY THIS ZONAL INSPECTION. 80-123-Maintenance 1999M.1C.80-123 5093830 12/1212016 03/07/2017 03/07/2017 Printed: 8(2712018 1:23:21PM Page 9 of 126 EFTA00798631  Project: 1999M Work Order Detail Aircraft: 737 - 32806 comlux Repair Station: 166-CAY-AMO-20 Task Card # Task ID Opened RTS Closed Description: 53-900-001NTERNAL - ZONAL (GV): APU COMPARTMENT. PERFORM AN INTERNAL ZONAL INSPECTION (GV) OF THE APU COMPARTMENT - SECTION 48. STA 1088 TO STA 1156. (EZAP) THE EZAP INSPECTION REQUIREMENT WITH INTERVAL 5500 FC/3 YR IS SATISFIED BY THIS ZONAL INSPECTION. 80-124-Maintenance 1999M.1C.80-124 5093831 12/1212016 04/19/2017 04/1912017 Description: 53-902-00INTERNAL - ZONAL (GV): TAIL CONE. PERFORM AN INTERNAL ZONAL INSPECTION (GV) OF THE TAIL CONE - SECTION 48, STA 1156 TO STA 1217. (EZAP) THE EZAP INSPECTION REQUIREMENT WITH INTERVAL 18000 FC/6 YR IS SATISFIED BY THIS ZONAL INSPECTION. 80-125-Maintenance 1999M.1C.80-125 5093832 12/12(2016 04/03/2017 04/03/2017 Description: 53-904-01INTERNAL - ZONAL (GV): FLAP SUPPORT NO. 4 - L. WING. PERFORM AN INTERNAL ZONAL INSPECTION (GV) OF THE FLAP SUPPORT NO. 4 - LEFT WING - SECTION 46, STA 727. (EZAP) THE EZAP INSPECTION REQUIREMENT WITH INTERVAL 5500 FC/3 YR IS SATISFIED BY THIS ZONAL INSPECTION. ACCESS NOTE: FLAPS EXTENDED. 80-126-Maintenance 1999M.1C.80-126 5093833 12/12/2016 04/03/2017 04/03/2017 Description: 53-906-02INTERNAL - ZONAL (GV): FLAP SUPPORT NO.5 - R. WING. PERFORM AN INTERNAL ZONAL INSPECTION (GV) OF THE FLAP SUPPORT NO. 5 - RIGHT WING - SECTION 46. STA 727. (EZAP) THE EZAP INSPECTION REQUIREMENT WITH INTERVAL 5500 FC/3 YR IS SATISFIED BY THIS ZONAL INSPECTION. ACCESS NOTE: FLAPS EXTENDED. 80-128-Maintenance 1999M.1C.80-128 5093834 12/12/2016 03/07/2017 03/07/2017 Description: 54.040-01INTERNAL - GENERAL VISUAL: LEFT STRUT TO WING ATTACHMENTS. INSPECT STRUT TO WING UPPER LINK, DIAGONAL BRACE, SIDE LINKS, AND STRUT ATTACHMENT FITTINGS. 80-129-Maintenance 1999M.1C.80-129 5093835 12/12/2016 03/08/2017 03/08/2017 Description: 54-040-02INTERNAL - GENERAL VISUAL: RIGHT STRUT TO WING ATTACHMENTS. INSPECT STRUT TO WING UPPER LINK, DIAGONAL BRACE, SIDE LINKS, AND STRUT ATTACHMENT FITTINGS. 80-130-Maintenance 1999M.1C.80-130 5093836 12/12/2016 03/08/2017 03/08/2017 Description: 54-050-01INTERNAL - DETAILED: LEFT STRUT TO WING ATTACHMENTS. INSPECT PINS AND FUSE PINS ON UPPER LINK MIDSPAR, DIAGONAL BRACE, AND SIDE LINKS. PIN REMOVAL IS NOT REQUIRED. 80-131-Maintenance 1999M.1C.80-131 5093837 12/12/2016 03/08/2017 03/08/2017 Desaiption: 54-050-02INTERNAL - DETAILED: RIGHT STRUT TO WING ATTACHMENTS. INSPECT PINS AND FUSE PINS ON UPPER LINK. MIDSPAR, DIAGONAL BRACE, AND SIDE LINKS. PIN REMOVAL IS NOT REQUIRED. 80-132-Maintenance 1999M.1C.80-132 5093838 12/12/2016 03/10/2017 03/10/2017 Desaiption: 54-800-01INTERNAL - ZONAL (GV): FORWARD STRUT FAIRING - ENGINE NO. 1. PERFORM AN INTERNAL ZONAL INSPECTION (GV) OF THE FORWARD STRUT FAIRING - ENGINE NO. 1. (EZAP) THE EZAP INSPECTION REQUIREMENT WITH INTERVAL 18000 FC/6 YR IS SATISFIED BY THIS ZONAL INSPECTION. 80-133-Maintenance 1999M.1C.80-133 5093839 12/12/2016 03/08/2017 03/08/2017 Description: 54-602-01INTERNAL - ZONAL (GV): FAN COWL SUPPORT BEAM - ENGINE NO.1. PERFORM AN INTERNAL ZONAL INSPECTION (GV) ON THE FAN COWL SUPPORT BEAM - ENGINE NO. 1. (EZAP) THE EZAP INSPECTION REQUIREMENT WITH INTERVAL 18000 FC/6 YR IS SATISFIED BY THIS ZONAL INSPECTION. 80-134-Maintenance 1999M.1C.80-134 5093840 12/12/2016 03/10/2017 03/10/2017 Description: 54-804-01INTERNAL - ZONAL (GV): STRUT TORQUE BOX - ENGINE NO. 1. PERFORM AN INTERNAL ZONAL INSPECTION (GV) OF THE STRUT TORQUE BOX - ENGINE NO. 1. (EZAP) THE EZAP INSPECTION REQUIREMENT WITH INTERVAL 18000 FC/6 YR IS SATISFIED BY THIS ZONAL INSPECTION. 80-135-Maintenance 1999M.1C.80-135 5093841 12/12/2016 03/08/2017 03/08/2017 Description: 54-806-01INTERNAL - ZONAL (GV): AFT STRUT FAIRING - ENGINE NO.1. PERFORM AN INTERNAL ZONAL INSPECTION (GV) OF THE AFT STRUT FAIRING - ENGINE NO. 1. (EZAP) THE EZAP INSPECTION REQUIREMENT WITH INTERVAL 12000 FC/4 YR IS SATISFIED BY THIS ZONAL INSPECTION. Printed: 8/2712018 1:23:21PM Page 10 of 128 EFTA00798632  Project: 1999M IcomluxWork Order Detail Aircraft: 737 - 32806 Repair Station: 166-CAY-AMO-20 Task Card # Task ID Opened RTS Closed 80-136-Maintenance 1999M.1C.80-136 5093842 12/12/2016 03/02/2017 03/02/2017 Description: 54-808-02INTERNAL - ZONAL (00: FORWARD STRUT FAIRING - ENGINE NO. 2. PERFORM AN INTERNAL ZONAL INSPECTION (GV) OF THE FORWARD STRUT FAIRING - ENGINE NO.2. (EZAP) THE EZAP INSPECTION REQUIREMENT WITH INTERVAL 18000 FC/6 YR IS SATISFIED BY THIS ZONAL INSPECTION. 80-137-Maintenance 1999M.1C.80-137 5093843 12/1212016 01/03/2018 01/05/2018 Description: 54-810-02INTERNAL - ZONAL (GV): FAN COWL SUPPORT BEAM - ENGINE NO.2. PERFORM AN INTERNAL ZONAL INSPECTION (GV) OF THE FAN COWL SUPPORT BEAM - ENGINE NO. 2. (EZAP) THE EZAP INSPECTION REQUIREMENT WITH INTERVAL 18000 FC/6 YR IS SATISFIED BY THIS ZONAL INSPECTION. 80-138-Maintenance 1999M.1C.80-138 5093844 12/1212016 01/03/2018 01/05/2018 Description: 54-812-02INTERNAL - ZONAL (00: STRUT TORQUE BOX - ENGINE NO. 2 PERFORM AN INTERNAL ZONAL INSPECTION (GV) OF THE STR